19 April 2006

Aviation, , , , , , , , , , , , , , , , ,
Albert Scott Crossfield, Jr., with the Victor Black Edition Continental engine overhauled by Victor Aviation of Palo Alto, California.
Albert Scott Crossfield, Jr., with the Victor Black Edition Continental IO-470-E engine installed in his Cessna 210A, N6579X. The engine was overhauled by Victor Aviation of Palo Alto, California. (Victor Aviation)

19 April 2006: Former experimental test pilot Albert Scott Crossfield, Jr., was enroute from Prattville, Alabama, to Manassas, Virginia. Scott Crossfield ¹ was flying his personal Cessna 210A, N6579X. The Cessna was cruising at 11,000 feet (3,353 meters) under Instrument Flight Rules (IFR), under the control of the Atlanta Air Route Traffic Control Center (ARTCC).

During the flight, he encountered a Level 6 thunderstorm.

Scott Crossfield requested to deviate from his planned course to avoid the severe turbulence. Atlanta Center authorized his request and he began to turn. Approximately 30 seconds later, at 11:10 a.m., radar contact was lost near Ludville, Georgia. The last indication was that the Cessna was descending through 5,500 feet (1,676 meters).

The wreckage of N6579X was located the following day by a Civil Air Patrol search team, 3.3 nautical miles (6.1 kilometers) northwest of Ludville at an elevation of 1,269 feet (386.8 meters) above Sea Level. [N. 34° 30.767′, W. 84° 39.492′] The airplane had descended through the forest canopy nearly vertically and created a crater approximately 4½ feet (1.4 meters) deep and 6 feet (1.8 meters) across. Albert Scott Crossfield’s body was inside.

Scott Crossfield’s 1962 Cessna 210A Centurion, photographed at Santa Monica Airport, California, 26 September 1999. (AirNikon Collection, Pima Air & Space Museum, Tucson, Arizona, via airliners.net. Image used with permission.)

N6579X was a Cessna Model 210A, serial number 21057579, built in 1960 by the Cessna Aircraft Company, Inc., of Wichita Kansas. It was a six-place, single-engine, high-wing monoplane with external struts to brace the wings, and retractable, tricycle landing gear. The airplane was certified for instrument flight by a single pilot. At the time of the crash, N6579X had been flown 4,987.4 hours, total time since new (TTSN).

The Cessna 210A was 28 feet, 2 inches (8.585 meters) long with a wingspan of 36 feet, 6 inches (11.125 meters) and overall height of 9 feet, 7 inches (2.921 meters). The airplane had an empty weight of 1,839 pounds (834.2 kilograms) and maximum gross weight of 2,900 pounds (1,315.4 kilograms). It had a fuel capacity of 65 gallons (246 liters), with 10 gallons (37.9 liters) unusable, and 12 quarts of engine oil (11.4 liters).

N6579X was powered by an air-cooled, fuel-injected, 471.239-cubic-inch-displacement (7.722 liters) Teledyne Continental IO-470-E horizontally-opposed six-cylinder direct-drive engine with a compression ratio of 8.6:1. The engine was rated at 260 horsepower at 2,625 r.p.m. for takeoff, using 100LL aviation gasoline. It weighed 429 pounds (195 kilograms). This engine, serial number 77583-0-E, was original to the airplane and accumulated 4,987.4 hours, total time since new (TTSN). It had been overhauled by Victor Aviation, Palo Alto, California, 1,259.8 hours prior to the accident (TSO). A three-bladed McCauley constant-speed propeller with a diameter of 6 feet, 10 inches (2.083 meters) was installed in 2005.

The Cessna Model 210A has a maximum structural cruise speed (VNO) of 175 miles per hour (282 kilometers), and maximum speed (VNE) of 200 miles per hour (322 kilometers per hour). Maneuvering speed, which should be used in turbulent conditions, is 130 miles per hour (209 kilometers per hour). The 210A has a maximum rate of climb of 1,300 feet per minutes (6.6  meters per second) and service ceiling of 20,700 feet (6,309 meters). Its maximum range is 1,284 miles (2,066 kilometers).

Albert Scott Crossfield, Jr., aeronautical engineer and test pilot, 1921-2006. (Jet Pilot Overseas)

Albert Scott Crossfield, Jr., was born 2 October 1921 at Berkeley, California. He was the second of three children of Albert Scott Crossfield, a chemist who was employed as the superintendant of the Union Oil Company refinery in Wilmington, California, and Lucia M. Dwyer Crossfield.

When he was five years old, young “Scotty” contracted pneumonia. He was comatose for a while and was not expected to survive, but after several weeks he began to recover. A year later, he again became seriously ill, this time with rheumatic fever. He was confined to total bed rest for four months, and continued to require extensive bed rest until he was about ten years old. It was during this time that he became interested in aviation.

Scott Crossfield attended Boistfort Consolidated School, southwest of Chehalis, Washington, graduating in 1939, and then studied engineering at the University of Washington until taking a job at Boeing in late 1941. During this time, Scotty learned to fly in the Civilian Aviation Training Program.

The week following the attack on Pearl Harbor and the United States’ entry into World War II, Scott Crossfield enlisted as an aviation cadet in the United States Army Air Corps. After numerous delays, he joined the United States Navy on 21 February 1942, and resigned from the Air Corps. He began aviation cadet training at NAS Sand Point, near Seattle, and then was sent to NAS Corpus Christi, Texas. In December 1942, he graduated, received his gold Naval Aviator wings and was commissioned as an Ensign, United States Naval Reserve.

Ensign Crossfield was assigned to NAS Kingsville, near Kingsville, Texas, as an advanced bombing and gunnery instructor.

In April 1943 at Corpus Christi, Texas, Ensign A. Scott Crossfield married Miss Alice Virginia Knoph of Seattle. They would have nine children.

Ensign Crossfield served as a gunnery instructor for two years. He was promoted to Lieutenant (junior grade), 1 March 1944. In 1945 he was transferred to Air Group 51 in the Hawaiian Islands, which was preparing for the invasion of Japan. Crossfield was promoted to Lieutenant, 1 August 1945, while serving aboard the Independence-class light aircraft carrier USS Langley (CVL-27). With the end of World War II, though, the Navy was cutting back. Lieutenant Crossfield was released from active duty 31 December 1945.

Following the War, Scotty returned to the University of Washington to complete his degree. He took a part time job operating the University’s wind tunnel. At the same time, he remained in the Naval Reserve, assigned to VF-74, a fighter squadron which flew both the Grumman F6F Hellcat and Chance Vought F4U Corsair out of NAS Sand Point, back where his naval career began.

Chance Vought F4U-4 Corsair, Bu. No. 82034, assigned to Fighter Squadron 74 (VF-74). (United States Navy)

Crossfield graduated from the University of Washington with a bachelor’s degree in aeronautical engineering in June 1949, and a master’s degree in 1950.

In 1950 Crossfield joined the National Advisory Committee for Aeronautics (NACA) as a research test pilot at the High-Speed Flight Station, Edwards Air Force Base, California. He flew the Republic YF-84, F-84F Thunderstreak, and North American Aviation F-86 Sabre. Crossfield made 25 flights in the delta-winged Convair XF-92A, which he described as “the worst flying airplane built in modern times.” He also flew the Northrop X-4 and Bell X-5. He made 17 flights conducting stability tests in the Douglas D-558-1 Skystreak. Scotty made 65 flights in the North American Aviation F-100A Super Sabre, including a test series which discovered a fatal flaw which led to the death of North American’s chief test pilot, George S. Welch.

NACA Research Test Pilot Albert Scott Crossfield in the cockpit of the Douglas D-558-II Skyrocket after exceeding Mach 2, 20 November 1953. (NASA)

Crossfield is known as a rocketplane pilot. He made 10 flights in the Bell X-1, 89 in the Douglas D-558-II Skyrocket, and 14 in the North American Aviation X-15. He became the first pilot to exceed Mach 2 when he flew the Skyrocket to Mach 2.005, 20 November 1953.

Scott Crossfield discusses the X-15 with North American Aviation engineers Edmond R. Cokeley and Charles H. Feltz. (North American Aviation, Inc.)

Crossfield flew for NACA for approximately five years. During that time, approximately 500 flights were made at Edwards by NACA test pilots. Scott Crossfield flew 181 of them.

Scott Crossfield left NACA in 1956 to join North American Aviation, Inc., as chief engineering test pilot for the X-15 project. Between 8 June 1959 and 6 December 1960, he made fourteen flights in the X-15. He reached a maximum speed of Mach 2.97 and altitude of 88,116 feet (26,858 meters). Once the contractor’s flight tests were completed and the rocketplane turned over to the U.S. Air Force and NACA, the customers’ test pilots, Joe Walker and Major Robert M. White, took over.

Albert Scott Crossfield made 113 flights in rocket-powered aircraft, more than any other pilot.

After completing his work on the X-15, Crossfield followed Harrison (“Stormy”) Storms, who had been the Chief Engineer of North American’s Los Angeles Division (where the X-15 was built) to the Space and Information Systems Division in Downey, California, where he worked in quality assurance, reliability engineering and systems testing for the Apollo Command and Service Modules and the Saturn S-II second stage.

Crossfield left North American at the end of 1966, becoming Vice President for Technological Development for Eastern Air Lines. In this position, he flew acceptance tests for new Boeing 720 and 727 airliners at Boeing in Seattle.

In The X-15 Rocket Plane, author Michelle Evans quoted Crossfield as to why he had not entered NASA’s space program as an astronaut:

    One question that pressed was, with his love of flight and the early responsibility of going into space with the X-15, why would Scott not apply to the NASA astronaut office? He explained, “[Dr.] Randy Lovelace and General [Donald] Flickinger were on the selection board. They took me to supper one night and asked me not to put in for astronaut. I asked them, ‘Why  not?’ and they said, ‘Well, we’re friends of yours. We don’t want to have to turn you down.’ I asked, ‘Why would you have to turn me down?’ and they said, ‘You’re too independent.’ “

—The X-15 Rocket Plane: Flying the First Wings into Space, by Michelle, Evans, University of Nebraska Press, 2013, Chapter 1 at Page 33.

The remains of Albert Scott Crossfield are interred at the Arlington National Cemetery.

Scott Crossfield is in the cockpit of X-15 56-6670, under the right wing of NB-52A 52-003. (NASA)

¹ “Scott Crossfield” is the family name, going back for several generations.

© 2017, Bryan R. Swopes

Medal of Honor, Major Leo Keith Thorsness, United States Air Force

Aviation, , , , , , , , , , , , ,
Lieutenant Colonel Leo Keith Thorsness, United States Air Force. (U.S. Air Force)

MEDAL OF HONOR

LIEUTENANT COLONEL LEO K. THORSNESS
UNITED STATES AIR FORCE

Rank and organization: Lieutenant Colonel (then Major), U.S. Air Force, 357th Tactical Fighter Squadron

Place and date: Over North Vietnam, 19 April 1967.

Entered service at: Walnut Grove, Minn.

Born: 14 February 1932, Walnut Grove, Minn.

Medal of HonorCitation: For conspicuous gallantry and intrepidity in action at the risk of his life above and beyond the call of duty. As pilot of an F- 105 aircraft, Lt. Col. Thorsness was on a surface-to-air missile suppression mission over North Vietnam. Lt. Col. Thorsness and his wingman attacked and silenced a surface-to-air missile site with air-to-ground missiles, and then destroyed a second surface-to-air missile site with bombs. In the attack on the second missile site, Lt. Col. Thorsness’ wingman was shot down by intensive antiaircraft fire, and the 2 crewmembers abandoned their aircraft. Lt. Col. Thorsness circled the descending parachutes to keep the crewmembers in sight and relay their position to the Search and Rescue Center. During this maneuver, a MIG-17 was sighted in the area. Lt. Col. Thorsness immediately initiated an attack and destroyed the MIG. Because his aircraft was low on fuel, he was forced to depart the area in search of a tanker. Upon being advised that 2 helicopters were orbiting over the downed crew’s position and that there were hostile MiGs in the area posing a serious threat to the helicopters, Lt. Col. Thorsness, despite his low fuel condition, decided to return alone through a hostile environment of surface-to-air missile and antiaircraft defenses to the downed crew’s position. As he approached the area, he spotted 4 MIG-17 aircraft and immediately initiated an attack on the MlGs, damaging 1 and driving the others away from the rescue scene. When it became apparent that an aircraft in the area was critically low on fuel and the crew would have to abandon the aircraft unless they could reach a tanker, Lt. Col. Thorsness, although critically short on fuel himself, helped to avert further possible loss of life and a friendly aircraft by recovering at a forward operating base, thus allowing the aircraft in emergency fuel condition to refuel safely. Lt. Col. Thorsness’ extraordinary heroism, self-sacrifice, and personal bravery involving conspicuous risk of life were in the highest traditions of the military service, and have reflected great credit upon himself and the U.S. Air Force.

Major Leo K. Thorsness and Captain Harold E. Johnson with their Republic F-105F Thunderchief, Takhli Royal Thai Air Force Base, Thailand, 1967. (U.S. Air Force)
Major Leo K. Thorsness and Captain Harold E. Johnson with their Republic F-105F Thunderchief, Takhli Royal Thai Air Force Base, Thailand, 1967. (U.S. Air Force)

AIR FORCE CROSS

CAPTAIN HAROLD EUGENE JOHNSON

Air Force Cross
Air Force Cross

The President of the United States of America, authorized by Title 10, Section 8742, United States Code, takes pleasure in presenting the Air Force Cross to Captain Harold Eugene Johnson (AFSN: 0-3116556/42372A), United States Air Force, for extraordinary heroism as Electronics Warfare Officer of an F-105 aircraft of the 357th Tactical Fighter Squadron, 355th Tactical Fighter Wing, Tuy Hoa Air Base, Vietnam, engaged in a pre-strike, missile suppression mission over North Vietnam on 19 April 1967. On that date, Captain Johnson guided his pilot in attacking and destroying a surface-to-air missile installation with an air-to-ground missile. Through his technical skill, he immediately detected a second missile complex and guided the pilot into visual contact. Diving into a deadly barrage of anti-aircraft fire, his aircraft bombed and successfully destroyed this site. In the attack on this second missile site, a wingman was shot down by the intense anti-aircraft fire, and the crew members were forced to abandon their aircraft. Flying through hostile missile threats, Captain Johnson’s aircraft engaged and destroyed a MiG-17 while attacking a superior MiG force. He aided in the rescue efforts for the downed crew, engaged additional MiGs, and damaged one in the encounter. Through his extraordinary heroism, superb airmanship, and aggressiveness, Captain Johnson has reflected the highest credit upon himself and the United States Air Force.

General Orders: Department of the Air Force, Special Order GB-363 (April 19, 1967)

Action Date: 19-Apr-67

Service: Air Force

Rank: Captain

Company: 357th Tactical Fighter Squadron

Regiment: 355th Tactical Fighter Wing

Division: Tuy Hoa Air Base, Vietnam

Major Thorsness and Captain Johnson flew this Republic F-105F-1-RE Thunderchief, 63-8301, on 19 April 1967. It was one of 61 F-105Fs that were upgraded to the F-105G Wild Weasel III configuration beginning in late 1967. It survived the Vietnam War, but was destroyed 20 December 1974 when, assigned to the 35th TFW at George AFB, California, it crashed at the Cuddeback Lake Gunnery Range after an engine failure. (U.S. Air Force)
Major Thorsness and Captain Johnson flew this Republic F-105F-1-RE Thunderchief, 63-8301, on 19 April 1967. It was one of 61 F-105Fs that were upgraded to the F-105G Wild Weasel III configuration beginning in late 1967. It survived the Vietnam War, but was destroyed 20 December 1974 when, assigned to the 35th TFW at George AFB, California, it crashed at the Cuddeback Lake Gunnery Range after an engine failure. (U.S. Air Force)

A description of the air battle follows:

The first MiG kill of the day was recorded by Maj. Leo K. Thorsness, pilot, and Capt. Harold E. Johnson, Electronic Warfare officer (EWO), flying an F-105F. Thorsness’ flight consisted of four F-105F Wild Weasel aircraft, each plane being manned by a pilot and EWO and being specially equipped to locate and attack SAM sites. The flight was ahead of the main strike force and was committed to suppress SAM activity in the target area. About 8 to 10 MiG-17s attacked as the flight prepared to strike a SAM radar site with Shrike air-to-ground missiles. The Thorsness flight split up into three parts: the third and fourth aircraft entered into separate MiG engagements while Thorsness and his wingman continued the attack against the radar. The time was then about 4:55 p.m. Johnson provides an account of the encounter:

We found and delivered our ordnance on an occupied SAM site. As we pulled off the site heading west, Kingfish 02 ¹ called that he had an overheat light. He also headed west, and the crew, Majors Thomas M. Madison, pilot, and Thomas J. Sterling, EWO, had to eject from their aircraft. We headed toward them by following the UHF-DF steer we received from their electronic beepers and saw them in the chutes. . .

As we circled the descending crew, we were on a southerly heading when I spotted a MiG-17 heading east, low at out 9 o’clock position. I called him to the attention of Major Thorsness. . . .

Thorsness continued the story:

The MiG was heading east and was approximately 2,500 feet mean sea level. We were heading southeast and at 8,000 feet MSL. I began “S” turning to get behind the MiG. After one and a half “S” turns the MiG had progressed from the foothills over the delta southwest of Hanoi. The MiG turned to a northerly heading, maintaining approximately the same altitude and airspeed. Captain Johnson continued to give me SAM bearings, SAM-PRF [pulse recurrence frequency] status and launch indications as I continued to maneuver to attain a 6 o’clock position on the MiG.

The first burst of approximately 300 rounds of 20 mm was fired from an estimated 2,000–1,500 feet in a right hand shallow pursuit curve, firing with a cased sight reticle. No impacts were observed on the MiG. Within a few seconds we were in the 6 o’clock position with approximately 75 to 100 knots overtake speed. I fired another burst of approximately 300 rounds of 20 mm. I pulled up to avoid both the debris and the MiG. While pulling up I rolled slightly to the right, then left. The MiG was approximately 100 feet low and to our left, rolling to the right. The two red stars were clearly discernible, one on top of each wing, and several rips were noted on the battered left wing. We continued to turn to the left and after turning approximately 130° again sighted the MiG, still in a right descending spiral. Just prior to the MiG’s impacting the ground, Captain Johnson sighted a MiG-17 at our 6:30 position approximately 2,000 feet back. I pulled into a tighter left turn, selected afterburner, and lowered the nose. I again looked at the crippled MiG, saw it impact the ground in what appeared to be a rice field. After confirming the MiG had in fact impacted the ground I made a hard reversal and descended very near the ground, heading generally westerly into the foothills.

Thorsness then left the battle area, but returned after refueling to provide rescue combat air patrol during the search for his wingman’s aircrew. Thorsness and Johnson attacked another MiG and scored some damaging hits before they were themselves attacked by other MiG-17s. Although it is highly probable that Thorsness and Johnson destroyed a second MiG, this kill was not confirmed.

— Aces and Aerial Victories: The United States Air Force in Southeast Asia 1965–1973, by R. Frank Futrell, William H. Greenhalgh, Carl Grubb, Gerard E. Hasselwander, Robert F. Jakob and Charles A. Ravenstein, Office of Air Force History, Headquarters USAF, 1976, Chapter II at Pages 46 and 47.

Eleven days later, 30 April 1967, Major Thorsness and Captain Johnson were shot down by an AA-2A Atoll heat-seeking missile fired by a MiG-21 fighter piloted by Vũ Ngọc Đỉnh, 921st Fighter Regiment, Vietnam People’s Air Force. They ejected but were captured. Both men were held as Prisoners of War until 4 March 1973.

Colonel Leo Keith Thorsness, United States Air Force (Retired) died Tuesday, 2 May 2017, at St. Augustine, Florida. He was 85 years of age.

¹ Radio call sign for aircraft 2.

© 2019, Bryan R. Swopes

19 April 1960

Aviation, , , , , , , ,
Grumman YA2F-1 Inruder Bu. No. 147864 (San Diego Air and Space Museum Archives)
Grumman YA2F-1 Intruder Bu. No. 147864 with landing gear extended during the first flight, 19 April 1960. (San Diego Air and Space Museum Archives)

19 April 1960: Grumman Aircraft Engineering Corporation test pilot Robert K. Smyth made the first flight of the prototype YA2F-1 Intruder, Bu. No. 147864, at the Grumman Peconic River Airport (CTO), Calverton, Long Island, New York. During the flight, Smyth climbed to 15,000 feet (4,572 meters). The landing gear remained extended during the flight. At one point, Smyth attempted to retract it, but a malfunction was indicated, so they remained down and locked. The first flight lasted one hour.

During follow-on flights, Bob Smyth and project test pilot Ernie von der Heyden (who flew the photo-chase plane during the first flight) alternated left and right seats.

Bu. No. 147864 was painted gray with U.S. Navy markings before being accepted by the Navy on 29 April 1960. The airplane was lost 31 May 1960.

Grumman test pilot Robert K. Smyth in the cockpit of the YA2F-1 prototype, Bu. No. 147864, 29 April 1960. With Program manager Bruce Tuttle and VP Larry Mead. (Photograph courtesy of Neil Corbett, Test and Research Pilots, Flight Test Engineers)
Grumman test pilot Robert K. Smyth in the cockpit of the YA2F-1 prototype, Bu. No. 147864, 29 April 1960. With Program manager Bruce Tuttle and VP Larry Mead. (Photograph courtesy of Neil Corbett, Test and Research Pilots, Flight Test Engineers)

Eight Grumman YA2F-1 Intruders were built for the test program.  They were redesignated A-6A Intruder in 1962.

The Grumman A-6A Intruder was a carrier-based, all-weather attack bomber powered by two turbojet engines. It was operated by a pilot and a bombardier/navigator, or “b/n,” in a side-by-side cockpit. The wings were slightly swept.

The A2F-1 was 53 feet, 3 inches (16.231 meters) long with a wing span of 53 feet, 0 inches (16.154 meters) and overall height of 15 feet, 2 inches (4.623 meters). The wings had a total area of 528.9 square feet (49.14 square meters) and were swept aft to 25° at 25% chord. The aircraft had an empty weight of 23,412 pounds (10,620 kilograms) and maximum takeoff weight of 53,278 pounds (24,166 kilograms).

Grumman YA2F-1 Intruder, Bu. No. 147864, in Navy markings. (San Diego Air and Space Museum Archives)
Grumman YA2F-1 Intruder, Bu. No. 147864, in Navy markings. (San Diego Air & Space Museum Archives)
Grumman A2F-1 Intruder (A-6A) three-view illustration with dimensions. (U.S. Navy)

The prototypes were powered by two Pratt & Whitney J52-P-6 turbojet engines which had previously been used on the North American Aviation AGM-28 Hound Dog cruise missile. The J52 was a two-spool, axial-flow turbojet with a 12-stage compressor section (5 low- and 7 high-pressure stages) and 2-stage (1 high- and 1-low pressure stages). The engines had a normal power rating of 7,500 pounds of thrust (33.36 kilonewtons) at 11,400 r.p.m., and a maximum of 8,500 pounds (37.81 kilonewtons) at 11,650 r.p.m. The J52-P-6 was 31 inches (0.787 meters) in diameter, 127 inches (3.226 meters) long, and weighed 2,056 pounds (933 kilograms) The engine incorporated an exhaust nozzle that could be swiveled downward 23° to assist in short field takeoffs.

The A-6A had a cruise speed of 429 knots (493 miles per hour/795 kilometers per hour) at 44,450 feet (13,548 meters) and a maximum speed of 566 knots (651 miles per hour/1,048 kilometers per hour) at Sea Level. The service ceiling was 48,250 feet (14,707 meters), and the maximum range was 2,061 nautical miles (2,372 statute miles/3,817 kilometers).

The initial production Intruders could carry 18,000 pounds ( kilograms) of bombs on hardpoints under the wings. It could also carry AIM-9 Sidewinder air to air, or AGM-12 Bullpup air to ground missiles. “Special Weapons” that could be carried included Mk. 28 or Mk. 43 thermonuclear bombs.

The Intruder was a very successful combat aircraft with 693 built in attack, tanker and electronic warfare variants. They remained in service with the United States Navy until 1997.

Grumman YA2F-1 (A-6A) Intruder Bu. No. 147867, the third prototype, carrying thirty Mk. 82 low-drag bombs on multiple ejector racks under the wings and fuselage. (U.S. Navy)
Grumman YA2F-1 (A-6A) Intruder Bu. No. 147867, the third prototype, carrying thirty Mk. 82 low-drag 500-pound bombs on multiple ejector racks under the wings and fuselage. (U.S. Navy)

© 2019 Bryan R. Swopes

19 April 1955

Aviation, , , , , , , , , , , , , ,
Lockheed XF-104 Starfighter 083-1002, serial number 53-7787, the second prototype, in flight near Edwards AFB. (Lockheed Martin/Code One Magazine)

19 April 1955:¹ Lockheed test pilot Herman Richard (“Fish”) Salmon was flying the second prototype Lockheed XF-104 interceptor, 53-7787, conducting tests of the General Electric T171 Vulcan gun system.

At 47,000 feet (14,326 meters), Salmon fired two bursts from the T171. On the second burst, vibrations from the gun loosened the airplane’s ejection hatch, located beneath the cockpit, resulting in explosive decompression.

Lockheed Chief Test Pilot Anthony W. LeVier (left) and Test Pilot Herman R. Salmon. An F-104 Starfighter is behind them. (Lockheed)
Lockheed Chief Test Pilot Anthony W. LeVier (left) and Test Pilot Herman R. Salmon. An F-104 Starfighter is behind them. (Lockheed Martin)

The Associated Press reported:

Test Pilot Leaps From New Jet

     INYOKERN, Calif., April 20 (AP)—Herman R. (Fish) Salmon, former racing pilot and now a top test pilot, bailed safely from one of the Air Force’s hot new F104 jet fighters over the Mojave dessert[sic]Tuesday.

He was  spotted on the desert after a two-hour search by military planes and brought to the Naval ordinance [sic] test station here for a physical examination. A preliminary checkup indicated he was not injured.

     Salmon, 41, was on a routine test flight when he hit the silk. Authorities gave no hint what happened to the supersecret plane to make the bailout necessary. The craft’s height at the time it was abandoned was not given. The plane’s top speed has been unofficially estimated at 1,200 m. p. h.

     Wreckage of the F104, one of two prototypes now being tested by Lockheed Aircraft Corp. for the Air Force, was found several miles south of the China Lake area.

     A Lockheed spokesman said Salmon, of Van Nuys, Calif., was spotted by a search plane and apparently picked up by a Navy helicopter and flown here. Salmon took off on the test flight from Palmdale, about 70 miles south of here.

— Reno Evening Gazette, Volume LXXIX, Number 21, Wednesday, 20 April 1955, Page 24 at Columns 5–7.

Fish Salmon was wearing a David Clark Co. T-1 capstan-type partial-pressure suit and International Latex Corporation (I.L.C. Dover) K-1 helmet for protection in just such an emergency. The capstans are pneumatic tubes surrounded by fabric lacings, running along the arms, torso and legs. As the tubes inflated, the lacings pulled the fabric of the suit very tight and applied pressure to his body as a substitute for normal atmospheric pressure. The partial-pressure garment also enclosed his head, with a fiberglass helmet and a clear visor or face plate providing for vision.

Test pilot Herman R. Salmon with a prototype Lockheed XF-104 parked on Rogers Dry Lake. (Lockheed Martin)
Test pilot Herman R. (“Fish”) Salmon with a prototype Lockheed XF-104, parked on Rogers Dry Lake. (Lockheed Martin)

The sudden loss of cabin pressure and drop to subfreezing temperatures caused Salmon’s face plate to fog over. Inflating air bladders pushed his helmet high on his head.  The cockpit was filled with dust, fiberglass insulation and other debris. All this restricted his visibility, both inside and outside the airplane. The very tight pressure suit restricted his movements.

Fish Salmon cut the throttle, opened the speed brakes and began a descending turn to the left to reach a lower altitude. By the time he had reached 15,000 feet (4,572 meters) he had been unable to find a place on the desert floor to make an emergency landing. It was time to leave the crippled XF-104.

At 250 knots (288 miles per hour/463 kilometers per hour) the ejection seat fired Salmon out of the bottom of the cockpit. He had to open his parachute manually (the seat timer did not operate) and he made a safe landing.

The XF-104 had a downward-firing ejection seat, intended to avoid the airplane's tall vertical tail. Production aircraft used an upward-firing seat. (Lockheed)
The XF-104 had a downward-firing ejection seat, built by Stanley Aviation Inc. It was intended to avoid the airplane’s tall vertical tail. Later production aircraft used an upward-firing Martin-Baker seat. This airplane is the second prototype XF-104, 53-7787. (Lockheed Martin)

The prototype XF-104 impacted the desert approximately 73 miles (117 kilometers) east-northeast of Edwards Air Force Base. It was completely destroyed. Fish Salmon landed about 2 miles (3.2 kilometers) away. He was found two hours later and rescued by an Air Force helicopter.

Occasionally, a satisfied user thanked the researchers at the Aero Medical Laboratory. One of these was Lockheed test pilot Herman R. “Fish” Salmon. On April 14, 1955, ¹ Salmon was flying the second XF-104 (53-7787) at 47,500 feet while wearing a T-1 suit, K-1 helmet, and strap-fastened boots. As he triggered the General Electric M61 Vulcan 20 mm cannon for a test firing, severe vibrations loosened the floor-mounted ejection hatch and the cockpit explosively depressurized at the same time as the engine flamed out. The suit inflated immediately. Repeated attempts to restart the engine failed, and Salmon ejected at 15,000 feet. Fish reported, “I landed in a field of rocks ranging from one foot to five feet in diameter. My right arm was injured and my head struck a rock. The K-1 helmet hard shell was cracked, but there was no injury to my head. It took me 10 to 15 minutes to get out of the suit with my injured arm. Rescue was effected [sic] by helicopter approximately two hour after escape.” Salmon reported that the K-1 helmet was excellent for rugged parachute landings, and his only complaint was that the visor may impair vision at extreme altitudes.”

—Dressing for Altitude: U.S. Aviation Pressure Suits—Wiley Post to Space Shuttle, by Dennis R., Jenkins, National Aeronautics and Space Administration SP–2011–595, Washington, D.C., 2012, Chapter 4 at Page 141.

Lockheed's Chief Test Pilot, Anthony W. ("Tony") LeVier, is wearing a David Clark Co. T-1 capstan-type partial-pressure suit and K-1 helmet. The first prototype XF-104, 53-7786, is behind him. (U.S. Air Force)
Lockheed’s Chief Test Pilot, Anthony W. (“Tony”) LeVier, is wearing a David Clark Co. T-1 capstan-type partial-pressure suit and International Latex Corporation K-1 helmet. The first prototype XF-104, 53-7786, is behind him. (Jet Pilot Overseas)

There were two Lockheed XF-104 prototypes. Initial flight testing was performed with 083-1001 (USAF serial number 53-7786). The second prototype, 083-1002 (53-7787) was the armament test aircraft. Both were single-seat, single-engine supersonic interceptors. The XF-104 was 49 feet, 2 inches (14.986 meters) long with a wingspan of 21 feet, 11 inches (6.680 meters) and overall height of 13 feet, 6 inches (4.115 meters). The prototypes had an empty weight of 11,500 pounds (5,216 kilograms) and maximum takeoff weight of 15,700 pounds (7,121 kilograms).

The production aircraft was planned for a General Electric J79 turbojet but that engine would not be ready soon enough, so both prototypes were designed to use a Buick-built J65-B-3, a licensed version of the British Armstrong Siddeley Sapphire turbojet engine. XF-104 53-7787 had been built with an afterburning Wright J65-W-7 turbojet, rated at 7,800 pounds of thrust, and 10,200 pounds of thrust with afterburner.

The XF-104 had a maximum speed of 1,324 miles per hour (2,131 kilometers per hour), a range of 800 miles (1,287 kilometers) and a service ceiling of 50,500 feet (15,392 meters).

The General Electric T171 Vulcan was a prototype 6-barrelled 20 mm “Gatling Gun” automatic cannon. The barrels were rotated at high speed by a hydraulic drive. The gun is capable of firing 6,000 rounds per minute. The initial production version was designated M61. The cannon system was installed in a weapons bay on the left side of the F-104, between the cockpit and engine intakes.

The first prototype Lockheed XF-104, 53-7786, was also destroyed, 11 July 1957, when the vertical fin was ripped off by uncontrollable flutter. The pilot, William C. Park, safely ejected.

¹ Reliable sources give the date of this incident as both 14 April and 19 April. Contemporary news reports, published Wednesday, 20 April 1955, say that the accident took place “yesterday” and “Tuesday,” suggesting that the correct date is 19 April.

© 2017, Bryan R. Swopes

19 April 1942

Aviation, ,
Brigadier General James Harold Doolittle, U.S. Army Air Forces, 1942. (U.S. Air Force)

19 April 1942: On the day following the Halsey-Doolittle Raid, Lieutenant Colonel James Harold Doolittle, United States Army Air Forces, the leader of the B-25 strike force, was advanced two grades to the rank of brigadier general.

(Doolittle had been promoted to lieutenant colonel on 2 January 1942, and served just 108 days in that grade. He did not hold the rank of colonel.)

Upon his return to the United States Brigadier General Doolittle was presented with the Medal of Honor by President Franklin D. Roosevelt in a ceremony at The White House.

His next assignment was to the Eighth Air Force as it prepared to deploy to Europe.

© 2018, Bryan R. Swopes